Author Topic: 2003 RM250 /KX500 conversion  (Read 14549 times)

0 Members and 1 Guest are viewing this topic.

Offline 510rider

  • Jr. Member
  • **
  • Posts: 35
Re: 2003 RM250 /KX500 conversion
« Reply #15 on: February 19, 2017, 12:18:06 PM »
Pretty much failed on my first attempt on the pipe. Anybody try just cutting the CR pipe where it attaches to the cylinder and welding the same straight part from a KX pipe.  This would mean running basically a CR500 pipe. Much easier to weld up however. Anybody got any suggestions????

Tank on and lined up. Engine sitting in frame with carb and air box connected. Still have to figure out a silencer.
Also, for some strange reason my clutch cover is binding when I try to install it. Locking up the kick starter???  Hmmmm...

Offline umberto

  • Administrator
  • Hero Member
  • *****
  • Posts: 2,488
  • First Ride 02-02-19
Re: 2003 RM250 /KX500 conversion
« Reply #16 on: February 19, 2017, 01:34:27 PM »
I tried that on my first attempt. The CR pipe runs too close to the cylinder to clear everything without major dents, and it hits the ignition cover. You can start with the CR pipe welded to the KX stub and add to it as necessary to gain clearance. That's what I did on my bike. I added a section at the first turn to space it out for the ignition cover, and then added a wedge on the big part of the pipe in front of the cylinder to turn it away from the motor a bit. It was 2 inches at the top and half an inch at the bottom. Even with that, I still had to do a couple of hammer adjustments. It's a lot of trial and error.
« Last Edit: February 19, 2017, 01:54:00 PM by umberto »
Perhaps I have a dirt bike addiction?

03 KX 250/88 KX 525/2017 KX250F - Goliath
17 KX250F/04 KX250
04 KX 250 - Lunchbox's Bike
05 KX 125/144

Offline 510rider

  • Jr. Member
  • **
  • Posts: 35
Re: 2003 RM250 /KX500 conversion
« Reply #17 on: February 27, 2017, 12:36:25 PM »
Just discovered my new race tech shock spring I got got my 89 KX 500 is the same one for the RM250 roller I am using!!!  Sweet!!!!

Offline 510rider

  • Jr. Member
  • **
  • Posts: 35
Re: 2003 RM250 /KX500 conversion
« Reply #18 on: March 13, 2017, 02:32:56 PM »

Getting ready to do the pipe.  So far this has been very straight forward!!!